Custom-Made Briefs, Suits And Vests


Custom Made Briefs

Custom-made pressure garments maintain effective pressure for 2-3 months and then must be replaced. Alternating between several garments will aid in lengthening the life of the garments, although, in some cases of weight change, or spurts of rapid growth in children, more frequent re-measurement and replacement may be necessary.

Common Options for Custom Body Briefs and Body Suits

Neckline
Regular — Neckline should be at the sternal notch.

Scoop — Neckline is dropped to below the sternal notch, from 1/2 to 3 or more inches. You specify the depth.

Turtleneck — A band is attached to the neckline in order to raise a collar from 3/4 inch to 21/2 inches high. You specify height.

NOTE: Pressure on the torso is achieved by stretching the garment across the body. A deep neckline may result in less pressure across the upper torso.

Zippers
Torso garments, such as vests, body briefs, and suits come with a zipper as a standard feature. Zippers are anterior by default for all torso garments. Many torso garment orders for toddlers and infants request a posterior zipper. Zippers for upper and lower extremities attached to torso garments would be considered optional features and should be specified on the Upper Extremity Chart or the Lower Extremity Chart, as appropriate.

Zippers on the torso, whether anterior or posterior, may be offset several inches in order to avoid a sensitive area. In “Additional Instruc-tions” specify which side to move the zipper to and how much. For example, “Offset zipper three inches left”.

Hook & Loop Zipper Stop Tab
Torso garment zippers may occasionally come open on some patients. To prevent this we can install a hook and loop tab across the zipper to hold it together.

Hook & Eye
Torso garment zippers may be very difficult to close for those with little or no hand or finger strength. You may consider requesting two or three hook & eye latches (the same hook & eye used to close a brassiere), for example, one at the bottom, one at the middle, and one at the top of a vest zipper to assist these patients. The hook & eye latches are installed inside the zipper bands so the patient can close the bottom hook & eye, then negotiate the zipper, then close the middle hook & eye, and then zip up to that level, and so on. Although most commonly requested for torso garment zippers, hook & eye closures are technically feasible for any zipper.

Expansion Panels
A panel of Insert Material, 1 – 3 inches wide, may be installed along the lateral side of a torso garment, from the bottom of the garment to the axilla. If the garment has sleeves, the expansion panel could be made continuous from the bottom of the garment to the end of the sleeve. Expansion panels may be used to allow for growth in the pediatric patient and minor fluctuations in patient measurements

Inserts
The default breast style is to construct a breast cup out of the regular material of the garment using the chest circumferences and brassiere cup size provided, however, breast panels may alternatively be constructed out of our stretchy Insert Material. Breast inserts are frequently requested for adult female patients. Sleeves that come with Sleeved Vests, Sleeved Body Briefs, and Sleeved Body Suits may have inserts in the anterior elbow crease to prevent bunching of the garment material.

Underarm Gussets
Some patients may experience discomfort and skin breakdown from the material rubbing in the axillae. A gusset is a wedge of Insert Material incorporated into the axilla. If an expansion panel has been requested, the gusset may be incorporated into the expansion panel.

Linings
Some patients find the neck band of a torso garment irritating. This may be alleviated by lining the neck band with Lining Material. We call this, “drapelining”, because the lining material is draped around the band. Similarly, zipper bands and arm holes of sleeveless torso garments may be drapelined to reduce rubbing.

Linings may be incorporated in torso garments in order to reduce the discomfort from rubbing. For a sleeved garment, axilla linings may be added.

Pubis Construction
The default pubis for a male lower torso/extremity garment is closed with a horizontal fly, while the default pubis for a female is closed with a soft crotch gusset. Specify “open pubis” and we make the garment with a large pubic opening.

Fabric Content
The fabrics described below are Nylon® Lycra® or Dorlastan® spandex and contain no latex. All pressure ranges are available in all fabric types, however, each fabric has its own stretch properties. A soft fabric with high stretch will “give” more as the patient moves, and may, therefore, be less suitable for large circumferences or very active patients. A heavier stretch-resistant fabric will tend to maintain a more consistent pressure, but may be irritating to sensitive skin. Be sure to indicate the diagnosis on the Order Form.

Regular Material
Default material for adults and children 11 years or older (except head and neck and hand garments, see below). This is a heavy open weave, with a maximum stretch resistance. Regular Material is available in all 30 Bio-Concepts garment colors.

Close Knit Material
Default material for children 10 and under and for elderly patients 75 and older. Also the default fabric for face masks, chin straps, and hand garments. This fabric is very similar to the Regular Matierial, however, the threads are much finer and the weave is slightly more open. Close Knit Material is available in all 30 Bio-Concepts colors.

LuxFab™
Our new LuxFab™ is a wonderful fabric for the vascular patient. It has great three-way stretch and durability. Many patients will benefit from a LuxFab garment in their lymphedema management program.

Soft Material
Patients with extremely sensitive areas of skin may not be ready for Regular Material or even Close Knit fabric. The skin side of our Soft Material is very smooth and the fabric is very light as well. We often construct whole garments of Soft Material for small children and the very elderly. Soft Material is available in all 30 Bio-Concepts colors.

Lining Material
We normally use Lining Material to line the inside of the garment over particularly sensitive areas, such as elbows, axillae, and knees. We can line entire garments as well. The lining material is very soft. Lining Material is available in all 30 Bio-Concepts colors.

Insert Material
Insert Material stretches well in every direction and conforms extremely well to irregular surfaces. Elbows, knees, chins, tops of heads, heels, abdomens, and other sites are good places for inserts. Because Insert Material conforms so well, we also use it to cover stumps and to end a mitten. Insert Material is available in all 30 Bio-Concepts colors.

Silon-TEX®
A revolutionary new material that we incorporate directly into the garment. Silon-TEX is a medical-grade silicone elastomer sheet bonded to a Lycra Spandex fabric. Silon-TEX may be sewn into the garment in virtually any configuration needed to treat troublesome hypertrophic and keloid scars. Typically, Silon-TEX is used as a lining, sewn into the inside of the material of the rest of the garment. Silon-TEX is available only in white.

Forms / Instructions

………………………………………………………………………………………………………………………………………………………………..

All of the Order Forms and Measurement Charts listed below contained in one file.
All of the Measuring Manual sections listed below in one file. Be sure to check out the Bio-Concepts YouTube Channel for training, information about compression, testimonials, and more.

………………………………………………………………………………………………………………………………………………………………..

This should be completed and transmitted with every custom garment order.
Detailed instructions for submitting orders and an example order form.
Watch the video:  Youtube

………………………………………………………………………………………………………………………………………………………………..

Includes upper and lower torso.
Procedures and an example measuring chart.
Watch the video: Youtube

………………………………………………………………………………………………………………………………………………………………..

For separate sleeves and sleeves attached to torso garments (for example, sleeves for a sleeved vest).
Procedures and an example measuring chart.
Watch the video: Youtube

………………………………………………………………………………………………………………………………………………………………..

Includes lower torso and legs, does not include foot measurements.
Procedures and an example measuring chart.
Watch the video: Youtube

………………………………………………………………………………………………………………………………………………………………..

Required for stockings with feet; includes Foot Measurement Chart, tracing primer and foot tracing form.
Procedures and an example measuring chart and tracing guide.
Watch the video: Youtube

………………………………………………………………………………………………………………………………………………………………..

To indicate the locations of special linings and other features.
Instructions for illustrating special features.

………………………………………………………………………………………………………………………………………………………………..